Improving the biotechnology of symbiotic bacterial concentrate
https://doi.org/10.20914/2310-1202-2022-4-89-95
Abstract
In the field of food technology, it is currently important to obtain bacterial concentrates with high yield and viability of microbial cells. Purposeful regulation of the technological parameters of the production of bacterial preparations has a significant impact on their quality and on the quality of finished food products. The results of research on improving the technology of liquid bacterial concentrate based on symbiotic starter culture for bakery production are presented. This bacterial concentrate consists of a consortium of microorganisms characteristic of the fermentation microflora of rye starter cultures. The optimal dose of inoculate application was determined in order to increase the biomass. A feature of the technology is a new approach to inoculate preparation and biomass production. In the production of symbiotic concentrate, it is important to optimize the composition of the nutrient medium, to create conditions for the growth of mesophilic lactobacilli and yeast that do not ferment lactose, characteristic of the fermentation microflora used in bakery production. To obtain biomass, a simple and cheap nutrient medium based on curd whey is used; the inoculum is a natural symbiotic starter culture for rye bread; due to the balanced composition of the medium, the process of biomass accumulation is intensified; biomass is characterized by a high titer of viable cells. A high survival rate of cells under infrared drying conditions has been established. The starter concentrate has high enzymatic activity, good lifting power, has a high titer of mesophilic lactobacilli and yeast that do not ferment lactose.
About the Authors
I. V. Boyarineva
Far Eastern Federal University
Dr. Sci. (Engin.), professor, bioeconomics and food security department, Ajax, 10, Russian Island, Vladivostok, 690922, Russia
I. S. Khamagaeva
East Siberian State Technological University of Technology and Management
Dr. Sci. (Engin.), professor, technology of animal products department, Klyuchevskaya str., 40 v, Ulan-Ude, 670013, Russia
References
1. Tikhonov I.V., Ruban E.A., Gryazneva T.N., Samuylenko A.Ya. et al. Biotechnology. St. Petersburg, GIORD, 2005. 792 p. (in Russian).
2. Nagyzbekkyzy E. et al. Selection of optimal parameters for cultivation of lactic acid bacteria strains that are promising as starter cultures in the development of direct fermentation. International Journal of Applied and Fundamental Research. 2019. no. 7. pp. 14–18. URL: https://applied-research.ru/ru/article/view? id=12791 (in Russian).
3. Volkova G.S., Kuksova E.V., Serba E.M. The study of biological inter-strain interactions and growth properties of industrial strains of lactic acid bacteria. Topical issues of the dairy industry, inter-industry technologies and quality management systems. 2020. vol. 1. no. 1(1). pp. 104–109. (in Russian).
4. Kovalevskaya V.S., Molodkina N.R., Timofeenko T.I. Study of biocompatibility and biotechnological properties of lactic acid bacteria. Scientific Works of the Kuban State Technological University. 2016. no. 14. pp. 284–288. (in Russian).
5. Malkova A.V., Irkitova A.N., Dudnik D.E. Biocompatibility of bacilli strains that are promising for inclusion in the composition of a microbial biological product. Bulletin of biotechnology and physico-chemical biology named after Yu.A. Ovchinnikov. 2022. vol. 18. no. 2. pp. 19–24. (in Russian).
6. Zandanova T.N., Gogoleva P.A. Selection of a nutrient medium for obtaining a bacterial concentrate of a microbial consortium. Vestnik KrasGAU. 2018. no. 5 (140). Available at: https://cyberleninka.ru/article/n/podbor-pitatelnoy-sredy-dlya-polucheniya-bakterialnogo-kontsentrata-mikrobnogo-konsortsiuma (in Russian).
7. Shelubkova N.S. et al. Optimization of the parameters of kneading pasta dough from composite flour. Bulletin of the Krasnoyarsk State Agrarian University. 2018. no. 5 (140). pp. 232-239. (in Russian).
8. De Vuyst L., Van Kerrebroeck S., Leroy F. Microbial ecology and process technology of sourdough fermentation. Adv. Appl. Microbiol. 2017. vol. 100. pp. 49-160. doi: 10.1016/bs.aambs. 2017.02.003
9. Akulich A.V., Samuylenko T.D. Analysis of the production cycle of brewing departments of bakery enterprises of the Republic of Belarus. Storage and processing of agricultural raw materials. 2020. vol. 4. pp. 128-138. doi:10.36107/spfp.2019.208 (in Russian).
10. Boyarineva I.V., Khamagaeva I.S. Investigation of the conditions of cultivation of the microflora of symbiotic sourdough for bakery production. Vestnik VSGTU. 2015. no. 2. pp. 74–80. (in Russian).
11. Morgan C.A., Herman N., White P.A., Vesey Morgan G. Preservation of microorganisms by drying. Journal of Microbiological Methods. 2006. vol. 66 (2). pp.183–193. doi: 10.1016/j.mimet.2006.02.017
12. Shilina A.A., Igonina E.D. Influence of the type of starter culture on the rate of reproduction of microorganisms and efficiency under production conditions. Baltic Sea Forum: materials of the VIII International Baltic Sea Forum: in 6 volumes, Kaliningrad, October 05–10, 2020. Kaliningrad: Kaliningrad State Technical University, 2020. pp. 138-142. (in Russian).
13. Bastías D.A., Johnson L.J., Card S.D. Symbiotic bacteria of plant-associated fungi: friends or foes? // Current opinion in plant biology. 2020. vol. 56. pp. 1-8.
14. Rai A.N. CRC Handbook of symbiotic cyanobacteria. CRC Press, 2018.
15. Checcucci A. et al. Creation and characterization of a genomically hybrid strain in the nitrogen-fixing symbiotic bacterium Sinorhizobium meliloti. ACS Synthetic Biology. 2018. vol. 7. no. 10. pp. 2365-2378.
16. Krishnan M. et al. Insect gut microbiome–An unexploited reserve for biotechnological application. Asian Pacific journal of tropical biomedicine. 2014. vol. 4. pp. S16-S21. doi: 10.12980/APJTB.4.2014C95
17. Bonnet S.I. et al. The tick microbiome: why non-pathogenic microorganisms matter in tick biology and pathogen transmission. Frontiers in cellular and infection microbiology. 2017. vol. 7. pp. 236. doi: 10.3389/fcimb.2017.00236
18. Shi Y.M., Hirschmann M., Shi Y.N., Ahmed S. et al. Global analysis of biosynthetic gene clusters reveals conserved and unique natural products in entomopathogenic nematode-symbiotic bacteria. Nature Chemistry. 2022. vol. 14. no. 6. pp. 701-712. doi: 10.1038/s41557-022-00923-2
19. Vigneron A., Masson F., Vallier A., Balmand S. et al. Insects recycle endosymbionts when the benefit is over. Current Biology. 2014. vol. 24. no. 19. pp. 2267-2273. doi: 10.1016/j.cub.2014.07.065
20. Calcott M.J. Ackerley D.F., Knight A., Keyzers R.A. et al. Secondary metabolism in the lichen symbiosis. Chemical Society Reviews. 2018. vol. 47. no. 5. pp. 1730-1760. doi: 10.1039/C7CS00431A
Review
For citations:
Boyarineva I.V., Khamagaeva I.S. Improving the biotechnology of symbiotic bacterial concentrate. Proceedings of the Voronezh State University of Engineering Technologies. 2022;84(4):89-95. (In Russ.) https://doi.org/10.20914/2310-1202-2022-4-89-95
Views:
319
Email this article 
Post a Comment 
