Preview

Proceedings of the Voronezh State University of Engineering Technologies

Advanced search

Energy saving technology of allocation of protein-bearing fractions from oilseeds with use of the paroezhektorny thermal pump

https://doi.org/10.20914/2310-1202-2019-2-35-40

Abstract

The production cycle of complex processing of oilseeds with receiving vegetable oil, soluble and insoluble fraction from mix of the crushed pressing with heated water is offered; a squirrel from soluble fraction, the dried-up insoluble fraction. The main basic decision on decrease in energy consumption was the optimum choice of temperature differences in the evaporator and sections of the two-section condenser when receiving drying agents, the cooling air and warm water. The deviation from these values inevitably leads to increase in the consumed energy: fall of temperature of boiling of coolant in the evaporator on 1 °C results in need of increase in a consumption of working steam in the ejector of the paroezhektorny thermal pump, and therefore to an energy overexpenditure for 5–7 %, and temperature increase of condensation on 1° C leads to increase in power consumption by 2.0–2.5 %. The offered technology expands borders of energy efficient interface of objects of various temperature potentials on the basis of utilization and recovery of secondary energy resources. Universal approach in creation of the competitive technology providing heat generation and cold weather for in common proceeding heattechnological processes is fully realized. Ecologically safe conditions in implementation of technology due to use of water as coolant, excepting use toxic, vzryvo – and fire-dangerous working environments and also at the expense of the organization of the closed recirculation schemes for material and power streams with considerable decrease in removal of secondary energy resources from the scheme warm and cold supply are created.

About the Authors

A. A. Shevtsov
Voronezh state university of engineering technologies
Russian Federation
Dr. Sci. (Engin.), professor, technology of fats, processes and apparatuses of chemical and food production department, Revolution Av., 19 Voronezh, 394036, Russia


T. N. Tertychnaya
Voronezh State Agrarian University named after Emperor Peter the Great
Dr. Sci. (Agric.), professor, technology for storage and processing of agricultural products department, str. Michurina str., 1, Voronezh, 394087, Russia


V. V. Tkach
Military training and research center of the air force “Air force Academy named after Professor N.E. Zhukovsky and Y.A. Gagarin”
Cand. Sci. (Engin.), senior lecturer, 208 general professional disciplines department, Old Bolsheviks str., 54a, Voronezh, 394064, Russia


N. A. Serdyukova
Military training and research center of the air force “Air force Academy named after Professor N.E. Zhukovsky and Y.A. Gagarin”
senior lecturer, 208 general professional disciplines department, Old Bolsheviks str., 54a, Voronezh, 394064, Russia


References

1. Kudinov P.I., Shchekoldina T.V., Slizkaya A.S. The current state and structure of world resources of vegetable protein. Izvestiya vuzov. Pishchevaya tekhnologiya [News of higher education institutions. Food technology]. 2012. no. 5–6. pp. 35–38. (in Russian).

2. Kompantsev D.V., Popov A.V., Privalov I.M., Stepanova E.F. Protein isolates from plant materials: a review of the current state and analysis of the prospects for the development of technologies for producing protein isolates from plant materials. Sovremennyye problemy nauki i obrazovaniya [Modern problems of science and education]. 2016. no. 1. pp. 58–69. (in Russian).

3. Karabutov V.V., Gorshkov L.M., Labeyko M.A., Fedyakina Z.P. Obtaining food protein products from seeds and sunflower meal and their use. Vestnik natsional'nogo tekhnicheskogo universiteta “KHPI” [Bulletin of the national technical university “HPI”]. 2008. vol. 43. pp. 9–13. (in Russian).

4. Shevtsov A.A., Bunin E.S., Tkach V.V., Serdyukova N.A. et al. Effective introduction of a vapor compression heat pump into a complex oilseed processing line. Khraneniye i pererabotka sel'khozsyr'ya [Storage and processing of agricultural raw materials]. 2018. no. 1. pp. 60–64. (in Russian).

5. Frolova L.N., Shevtsov A.A., Lytkina L.I., Vasilenko V.N., Rusina K.Yu. Liniya proizvodstva rastitelnogo masla [Vegetable oil production line]. Рatent RF, no. 2619278, 2017.

6. Shevtsov A.A., Tkach V.V., Saltykov S.N., Serdyukova N.A., Kopylov M.V. Sposob upravleniya komplexnoy pererabotki semyan maslichnyh kultur [The way to control the line of integrated processing of oilseeds]. Рatent RF, no. 2688467, 2019.

7. Chetverikova I.V., Shevtsov A.A., Tkach V.V., Serdyukova N.A. Sposob komplexnoy pererabotki semyan soi s vydeleniem beloksoderzhashchih fraktsiy [The method of complex processing of soybean seeds with the allocation of protein-containing fractions]. Рatent RF, no. 2689672, 2019.

8. Antipov S.T., Kretov I.T., Ostrikov A.N. et al. Machiny i apparaty pizhchevyh proizvodstv [Machines and equipment for food production: in 2 books]. Moscow, Vysshaya shkola, 2001. 680 p. (in Russian).

9. Ostrikov A.N. Protsessy i apparaty pizhchevyh proizvodstv [Processes and apparatuses of food production: textbook. for universities: in 2 books]. St. Petersburg, GIORD, 2007. 608 p. (in Russian).

10. Bambushek E.M., Bukharin N.N., Gerasimov E.D. et al. Teplovyye i konstruktivnyye racchyety holodilnyh mashin [Thermal and structural calculations of refrigeration machines]. Moscow, Mechanical engineering, 1987. 423 p. (in Russian).

11. Spitler J.D., Gehlin S.E.A. Thermal response testing for ground source heat pump systems—An historical review. Renewable and Sustainable Energy Reviews. 2015. vol. 50. pp. 1125–1137.

12. Renaldi R., Kiprakis A., Friedrich D. An optimisation framework for thermal energy storage integration in a residential heat pump heating system. Applied energy. 2017. vol. 186. pp. 520–529.


Review

For citations:


Shevtsov A.A., Tertychnaya T.N., Tkach V.V., Serdyukova N.A. Energy saving technology of allocation of protein-bearing fractions from oilseeds with use of the paroezhektorny thermal pump. Proceedings of the Voronezh State University of Engineering Technologies. 2019;81(2):35-40. (In Russ.) https://doi.org/10.20914/2310-1202-2019-2-35-40

Views: 647


Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 License.


ISSN 2226-910X (Print)
ISSN 2310-1202 (Online)